- Navigation
Results 21 to 30 of 51
Thread: Can't pass emissions
-
05-21-2015, 12:56 PM #21Founding Member
- Status
- Offline
- Join Date
- Sep 2008
- Name
- Jay
- Vehicle
- 93 Ultra Z
- Location
- Delaware
- Posts
- 3,144
This is the email i just sent the DMV
I have some questions about ODBI compliant cars and Emissions testing in Delaware. Since 2002 I have owned a 1993 Camaro Z28. The car has been pampered and very mildly modified over its life. It is basically my toy and a show car. It now has just over 66,000 miles, approx. 3300 miles a year average, but I am the 3rd owner and I can attest that I rarely put 2000 miles a year on it since I have owned it. In 2011 it pass inspection with no issues. My wife lost her job in 2012 and in an effort to save some money I stored the car in my garage until this year. I have the car insured as a Classic Car of Special Interest through Hagerty and they covered it for the storage duration. In the beginning of the month I took the car to the Wilmington DMV where I failed the hydrocarbon emissions on both high and low speed, and the NoX on low speed. The fuel in the car was approximately 2 years old and even with Sta-bil, it was probably bad. The technician said that was more than likely the issue and to drive it and do some basic maintenance.
I drove the car home and proceeded to do a tune up, drain the fuel tank, change the fuel filter, and put fresh fuel in the car. With the temporary tag we drove the car to Ocean City and back last weekend with no issues and averaged 21+ MPG. All seemed normal with the car. Nothing mechanically has changed with the car since 2011. I took it back to the Delaware City DMV last night for a recheck. Before we went, I topped it off with fresh fuel and drove it to get it up to operating temperature. We had to wait a bit in line, so the car was good at hot. The technician was very friendly and commented on how nice the car was. He then had many issues trying to do the test and admitted he didn’t do many of these type of tests. Another technician had to come over and clear the machine. We were about 40 minutes with the sniffer up the tail pipe before the test was started. I again failed the test with similar high numbers on hydrocarbons on both speeds, but the NoX was fine. Due the wait and the line forming behind me I decided to just head home.
So now to my questions. Since I do all my own maintenance to the car what do I have to do to prove I am trying to fix my problem? Unfortunately, even though my wife has a job now, I do not have the time and money to just throw at this car. Some states have exemptions for cars that do not drive many miles a year, could this be an option for me in Delaware? I want to fix the car if there is a problem, but I need to be able to legally drive the car to diagnose it and I can’t keep buying temporary tags. Also I travel a bit for my job, and my time is tight. My parents have several antique cars and I know Delaware law is 25 years old. My 1993 is getting very close. Due to the fact is it is rarely driven and when it I do drive it I am usually going to an event, can I get some kind of grace for an antique status?
I know it sounds like I am trying to get by on breaking a law, but honestly I am not. I am just trying to make sense of emission testing a car that passed before and won’t pass now and the only difference is that it was in storage. Any help or advice would be greatly appreciated. I still plan on troubleshooting the car, but my t-tag runs out June 6th and I have some business travel in the next 2 weeks. I would really like to get the car ready for the show season and be able to take my family back out. It has been a long time since we got to enjoy taking the car to events.
Thank you for your time
Jay Keenan
Last edited by jaysz2893; 05-21-2015 at 05:05 PM.
-
05-21-2015, 04:55 PM #22"The Rock"
- Status
- Offline
- Join Date
- Jul 2009
- Name
- Popo
- Vehicle
- 1996 Impala with the heart of the old camaro. 1993 Corvette..
- Location
- Shillington, Pennsylvania, United States
- Posts
- 61,345
U doubled the letter to the dmv... but other than that I am interested to see their response.
Our BIG MOMENT @ the 2012 LTXshootout
http://www.facebook.com/photo.php?v=521756391174175
1996 Camaro Z28: RIP 09/25/2016
1994 Trans Am GT: SOLD 05/2017
1985/1996GS clone: SOLD
1996 Impala SS H/C, LT, with true dual exhaust, 4.10s, lowered, with CPT trans, many cosmetic mods, and a whole lot more to come...
2002 Caddilac EscaladeL CAI, lowered, 6.0 , AWD..
-
05-21-2015, 05:02 PM #23Founding Member
- Status
- Offline
- Join Date
- Sep 2008
- Name
- Jay
- Vehicle
- 93 Ultra Z
- Location
- Delaware
- Posts
- 3,144
@popo8 - I saw that and will edit it. Thanks! I am interested too. Here is my tune. It looks like my fans are set too low and my mV for the o2's are too high? @sweet-94z28 @MoeHorsePower I'm willing to pay either of you to go through my bin and adjust. I have an ostrich so I don't have to burn chips. I am planning on data logging this weekend. It looks that my timing is set way up too. Mods are the LPE 211/219 cam, 1.6 rr's AIR/EGR delete, Long tubes with 4 wire o2 conversion, dual cat exhaust, MSD 6AL, MSD Coil, MSD Opti, Stock Platinum Delco plugs, 52mm BK TB, Ram Air, Accell 26lb Hr injectors. Otherwise car is stock.
------------------------
TunerPro Bin Data Export
------------------------
SOURCE FILE: C720 P1025 O1031 - Jay Keenan - 93 Z28 M6 3.23s - NO MPG - 211-219-112 26_ Accels ram-air hood - 93 octane _4.bin
SOURCE DEFINITION: DA3.htm
SCALAR: Mask ID 0xDA
SCALAR: Fuel Cutoff, 1st Gear (Eng Speed) 6301.54 RPM
SCALAR: Fuel Cutoff, 2nd Gear (Eng Speed) 6301.54 RPM
SCALAR: Fuel Cutoff, 3rd -> 6th Gear (Eng Speed) 6301.54 RPM
SCALAR: Fuel Resume Speed 255.00 MPH
SCALAR: Fuel Resume, 1st Gear (Eng Speed) 6261.40 RPM
SCALAR: Fuel Resume, 2nd Gear (Eng Speed) 6261.40 RPM
SCALAR: Fuel Resume, 3rd -> 6th Gear (Eng Speed) 6261.40 RPM
SCALAR: Fan 1 On Coolant Temp, Low MPH 89.00 Deg C
SCALAR: Fan 1 On Coolant Temp, High MPH 94.25 Deg C
SCALAR: Fan 2 On Coolant Temp, Low MPH 92.75 Deg C
SCALAR: Fan 2 On Coolant Temp, High MPH 98.00 Deg C
SCALAR: Fan Low MPH Hysteresis 3.75 Deg C
SCALAR: Fan High MPH Hysteresis 3.75 Deg C
SCALAR: Injector Flow Rate 25.60 #/hr
SCALAR: Cylinder Volume 712.77 cc
SCALAR: EGR Off, (TPS) 1.17 % TPS
SCALAR: EGR On, (TPS) 1.95 % TPS
SCALAR: EGR Off, (Low RPM Window) 0.00 RPM
SCALAR: EGR On, (Low RPM Window) 0.00 RPM
SCALAR: EGR Off, (High RPM Window) 0.00 RPM
SCALAR: EGR On, (High RPM Window) 0.00 RPM
SCALAR: EGR Off, (Low MAP Window) 36.23 Kpa
SCALAR: EGR On, (Low MAP Window) 38.81 Kpa
SCALAR: EGR Off, (High MAP Window) 94.16 Kpa
SCALAR: EGR On, (High MAP Window) 93.06 Kpa
SCALAR: TCC Lock Speed (Low Gears) 255.00 MPH
SCALAR: TCC Unlock Speed (Low Gears) 255.00 MPH
SCALAR: TCC Lock Speed (High Gear) 0.00 MPH
SCALAR: TCC Unlock Speed (High Gear) 0.00 MPH
SCALAR: PROM ID 6881.00
SCALAR: Fuel Cutoff Speed 255.00 MPH
SCALAR: Fan Low/High MPH Threshold 45.00 MPH
SCALAR: Min. Cool. Temp. for Closed Loop 32.75 Deg C
SCALAR: Min Cool Temp for Closed Loop, Cold MAT 59.75 Deg C
SCALAR: Canister Purge Enable MAP Threshold 4.00 Kpa
SCALAR: Canister Purge Enable TPS Threshold 0.00 % TPS
SCALAR: Air Injector Enable Cool Temp Threshold 150.50 Deg. C
SCALAR: EGR Enable Cool. Temp. Threshold 150.50 Deg. C
SCALAR: Cool Thresh For HighTemp PE TPS Thresh. 116.75 Deg. C
SCALAR: EGR On, Vehicle Speed 255.00 MPH
SCALAR: EGR Off, Vehicle Speed 255.00 MPH
SCALAR: TCC Unlock Prevention Speed Threshold 255.00 MPH
SCALAR: Minimum BLM Value 80.00
SCALAR: Maximum BLM Value 160.00
SCALAR: Road Speed Constant 43885.71 Pulses/Mi
SCALAR: Maximum Spark Advance 52.00 Deg.
SCALAR: Instrument Panel VSS Pulse Divisor 96.00
SCALAR: MAP Threshold To Enable Power Enrichment 80.00 Kpa
SCALAR: Min Coolant Temp for BLM Update 40.25 Deg. C
SCALAR: Max. Coolant Temp. for BLM Update 140.00 Deg. C
SCALAR: Min. MAP for BLM Update 20.00 Kpa
SCALAR: DFCO Enable RPM Threshold 1500.00 RPM
SCALAR: DFCO Disable RPM Threshold 1300.00 RPM
SCALAR: DFCO Enable MAP Threshold 28.06 kPa
SCALAR: DFCO Disable MAP Threshold 29.91 kPa
SCALAR: DFCO Disable RPM Decrease Threshold 1500.00 RPM
SCALAR: DFCO Enable Coolant Temp. Threshold 20.00 Deg. C
SCALAR: DFCO Enable TPS Threshold Hysteresis 0.39 %TPS
SCALAR: Throt. Follow Extend Decay Timer (Drive) 50.00 msec
SCALAR: Throt. Follow Extend Decay Timer (P/N) 62.50 msec
SCALAR: Throt Follower Extend Decay Timer Adder 1.95 ms/MPH
SCALAR: Stoichiometric AFR 14.60 AFR
SCALAR: Fast O2 Rich/Lean Threshold Hysteresis 0.00 mV
SCALAR: IAC Default Keep Alive Min Position 32.00 Steps
SCALAR: IAC Minimum Keep Alive Min Position 10.00 Steps
SCALAR: IAC Maximum Keep Alive Min Position 70.00 Steps
SCALAR: C.A.R.S. Enable Coolant Temp. Threshold 151.25 Deg. C
SCALAR: Low Octane ESC Retard Enable MAP 69.39 kPa
SCALAR: Low Oct ESC Retard Disable Delta MAP 11.09 kPa
SCALAR: Low Oct ESC Retard Enable Knock Retard 1.41 Deg.
SCALAR: Low Oct ESC Retard Increase Step Size 50.00 Counts
SCALAR: Low Oct ESC Retard Decrease Step Size 2.00 Counts
SCALAR: Knock Retard Enable RPM 500.00 RPM
SCALAR: Knock Retard Enable Speed 1.00 MPH
SCALAR: Knock Retard Enable Coolant Temp. -4.00 Deg. C
SCALAR: Minimum Integrator Value 100.00
SCALAR: Maximum Integrator Value 150.00
SCALAR: DFCO Enable MPH Threshold 20.00 MPH
SCALAR: Idle RPM Adder, A/C On 0.00 RPM
SCALAR: Minimum 1st Gear RPM/Vss Ratio 110.00 Ratio
SCALAR: Minimum 4th Gear RPM/Vss Ratio 33.00 Ratio
SCALAR: Maximum 4th Gear RPM/Vss Ratio 50.00 Ratio
FLAG: VATS Diagnostic (Error 46) Set
FLAG: VATS Select (X = Enabled) Set
FLAG: VSS Diagnostic (Error 24) Set
FLAG: Knock Diagnostic (Error 43) Set
FLAG: A/C Press. Sensor Fail (Error 66) Set
FLAG: A/C Press. Sensor Degraded (Error 67) Set
FLAG: A/C Relay Shorted (Error 68) Set
FLAG: A/C Clutch Circuit Open (Error 69) Set
FLAG: A/C Evap. Temp. Sensor Fail (Error 71) Set
FLAG: EGR Diagnostic (Error 32) Not Set
FLAG: Auto Trans (TCC = O, Manual = X) Set
FLAG: QDM #1 Diagnostic (Error 26) Not Set
FLAG: QDM #2 Diagnostic (Error 27) Set
FLAG: QDM #3 Diagnostic (Error 28) Set
FLAG: EST Grounded Diagnostic (Error 42) Set
FLAG: Left O2 Sensor Diagnostic (Error 13) Set
FLAG: Left O2 Sensor Lean Diag (Error 44) Set
FLAG: Left O2 Sensor Rich Diag (Error 45) Set
FLAG: Right O2 Sensor Diagnostic (Error 63) Set
FLAG: Right O2 Sensor Lean Diag. (Error 64) Set
FLAG: Right O2 Sensor Rich Diag. (Error 65) Set
FLAG: MAP High Diagnostic (Error 33) Set
FLAG: MAP Low Diagnostic (Error 34) Set
TABLE: Main Spark Advance Vs RPM Vs. Load
RPM MAP (Kpa)
25.00 30.00 35.00 40.00 45.00 50.00 55.00 60.00 65.00 70.00 75.00 80.00 85.00 90.00 95.00 100.00
4000.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 36.00 35.00 34.00 34.00
3600.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 36.00 35.00 34.00 34.00
3200.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 36.00 35.00 34.00 34.00
2800.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 36.00 35.00 34.00 34.00
2400.00 47.00 50.00 50.00 49.00 48.00 47.00 44.00 42.00 40.00 39.00 38.00 36.00 35.00 34.00 33.00 33.00
2200.00 47.00 50.00 50.00 49.00 48.00 47.00 44.00 42.00 40.00 39.00 37.00 35.00 34.00 34.00 32.00 32.00
2000.00 47.00 50.00 50.00 49.00 48.00 47.00 44.00 41.00 40.00 38.00 37.00 35.00 33.00 33.00 32.00 31.00
1800.00 47.00 50.00 50.00 49.00 48.00 47.00 44.00 41.00 40.00 38.00 37.00 35.00 32.00 32.00 31.00 30.00
1600.00 46.00 49.00 49.00 48.00 47.00 46.00 43.00 41.00 40.00 38.00 36.00 33.00 31.00 30.00 30.00 29.00
1400.00 44.00 47.00 47.00 46.00 45.00 44.00 41.00 40.00 39.00 37.00 34.00 32.00 30.00 28.00 28.00 27.00
1200.00 42.00 45.00 45.00 45.00 44.00 42.00 40.00 39.00 38.00 36.00 33.00 30.00 29.00 27.00 26.00 25.00
1000.00 39.00 43.00 43.00 43.00 42.00 40.00 38.00 37.00 36.00 35.00 31.00 29.00 29.00 26.00 25.00 23.00
800.00 37.00 41.00 41.00 41.00 40.00 38.00 37.00 36.00 35.00 33.00 30.00 28.00 28.00 25.00 24.00 22.00
600.00 35.00 38.00 39.00 38.00 38.00 36.00 35.00 34.00 33.00 32.00 29.00 27.00 26.00 24.00 23.00 21.00
400.00 34.00 36.00 36.00 36.00 36.00 34.00 33.00 31.00 29.00 28.00 26.00 25.00 24.00 22.00 21.00 20.00
200.00 30.00 31.00 31.00 31.00 31.00 29.00 28.00 27.00 25.00 24.00 22.00 22.00 21.00 19.00 17.00 15.00
0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
TABLE: Low Pulse Width Injector Offset Adder Vs. BPW
BPW (usec) Adder (usec)
0.00
1952.00 0.00
1891.00 15.26
1830.00 30.52
1769.00 30.52
1708.00 45.78
1647.00 45.78
1586.00 61.04
1525.00 76.30
1464.00 91.55
1403.00 91.55
1342.00 106.81
1281.00 106.81
1220.00 106.81
1159.00 137.33
1098.00 152.59
1037.00 167.85
976.00 198.37
915.00 259.40
854.00 305.18
793.00 366.22
732.00 427.25
671.00 488.29
610.00 534.07
549.00 610.36
488.00 671.40
TABLE: Main Spark Advance Vs RPM Vs. Load, (EXT)
RPM MAP (Kpa)
25.00 30.00 35.00 40.00 45.00 50.00 55.00 60.00 65.00 70.00 75.00 80.00 85.00 90.00 95.00 100.00
7500.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 38.00 38.00 38.00 39.00 39.00
7000.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 38.00 38.00 38.00 39.00 39.00
6500.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 38.00 38.00 38.00 39.00 39.00
6000.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 38.00 38.00 38.00 38.00 38.00
5500.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 37.00 37.00 37.00 37.00
5000.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 36.00 36.00 35.00 35.00
4500.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 36.00 35.00 34.00 34.00
4000.00 47.00 50.00 50.00 49.00 48.00 47.00 45.00 42.00 40.00 39.00 38.00 37.00 36.00 35.00 34.00 34.00
TABLE: Closed TPS Spark Advance Vs. RPM
RPM Deg Spark
4800 40.00
4400 40.00
4000 40.00
3600 40.00
3200 39.00
2800 38.00
2400 37.00
2000 36.00
1600 36.00
1200 35.00
800 34.00
400 34.00
0 0.00
TABLE: Maximum Knock Retard Vs. RPM (in P.E.)
RPM Deg Retard
6400 8.00
5600 8.00
4800 8.00
4000 8.00
3200 8.00
2400 8.00
1600 7.00
800 5.00
TABLE: Maximum Knock Retard Vs. MAP (not in P.E.)
Kpa Deg Retard
100 9.00
90 9.00
80 9.00
70 9.00
60 7.00
50 5.00
40 0.00
30 0.00
20 0.00
TABLE: Volumetric Efficiency Vs. RPM Vs. MAP
RPM MAP (Kpa)
20.00 25.00 30.00 35.00 40.00 45.00 50.00 55.00 60.00 65.00 70.00 75.00 80.00 85.00 90.00 95.00 100.00
2000.00 64.06 65.63 67.97 71.48 75.78 80.08 82.03 84.77 87.11 89.06 89.84 90.23 90.23 91.41 92.97 94.92 95.70
1900.00 64.84 66.41 69.14 72.27 76.56 81.25 83.59 84.38 85.16 87.50 88.67 89.06 89.06 90.23 91.41 92.97 94.14
1800.00 63.67 66.41 67.97 71.09 75.78 79.30 80.86 81.64 83.98 87.50 89.06 89.06 89.45 90.63 91.80 92.97 94.14
1700.00 62.89 65.63 69.14 71.09 73.44 76.95 78.52 79.30 82.03 86.33 87.50 87.89 89.06 90.23 91.41 92.97 93.75
1600.00 63.67 64.84 69.14 71.48 72.66 74.61 76.17 77.34 80.47 84.77 86.33 87.11 87.89 89.84 91.02 92.19 92.58
1500.00 62.89 64.45 68.75 70.70 72.27 73.44 74.22 75.39 78.13 81.25 83.59 84.38 86.33 87.89 89.06 90.63 91.02
1400.00 61.72 63.67 66.80 70.31 72.27 73.05 73.44 73.83 75.39 77.34 79.30 80.47 83.20 84.38 85.94 86.72 87.89
1300.00 60.55 63.28 65.63 69.92 71.48 71.09 72.27 72.66 72.66 74.61 76.95 78.52 80.47 82.03 83.20 84.38 85.94
1200.00 60.55 62.50 65.23 69.53 71.09 69.92 71.48 71.88 71.48 72.66 75.39 76.17 78.13 79.69 81.25 82.42 83.98
1100.00 58.98 60.16 63.67 67.97 69.14 67.58 69.14 70.31 69.92 71.09 73.05 73.83 76.56 78.13 79.69 81.25 82.42
1000.00 55.86 57.42 60.94 65.23 66.41 64.84 66.80 68.36 67.58 69.14 70.70 72.27 74.22 76.56 78.13 79.69 81.25
900.00 52.73 54.30 57.42 61.33 62.50 61.72 62.89 64.45 64.45 66.02 68.36 69.92 72.27 74.22 76.17 77.73 79.30
800.00 49.22 50.78 53.91 55.86 56.64 57.81 60.55 61.33 61.72 63.28 65.23 67.58 69.53 71.48 73.44 75.39 76.95
700.00 44.92 46.88 50.39 51.95 52.73 54.30 58.20 58.98 58.59 60.55 62.50 64.45 66.80 68.75 70.31 72.27 73.44
600.00 41.41 43.75 47.27 48.44 49.61 51.56 56.64 56.64 55.86 57.42 59.77 61.72 64.06 65.63 67.58 69.14 70.70
500.00 39.06 40.63 44.53 45.70 46.88 48.83 53.91 54.69 54.30 55.86 57.81 60.16 62.11 64.06 65.63 67.19 68.75
400.00 37.11 38.28 41.80 43.75 44.14 47.27 52.34 52.73 52.73 55.08 56.64 58.59 60.55 62.50 64.45 66.02 67.19
TABLE: Volumetric Efficiency Vs. RPM Vs. MAP (EXT)
RPM MAP (Kpa)
20.00 25.00 30.00 35.00 40.00 45.00 50.00 55.00 60.00 65.00 70.00 75.00 80.00 85.00 90.00 95.00 100.00
7000.00 84.38 87.89 89.06 91.41 92.19 92.97 91.41 91.80 98.44 99.61 99.61 99.61 99.61 99.61 99.61 99.61 99.61
6500.00 82.81 85.94 87.89 90.63 91.41 92.58 91.02 91.80 98.83 99.61 99.61 99.61 99.61 99.61 99.61 99.61 99.61
6000.00 83.20 87.50 89.06 92.58 94.92 96.09 93.75 98.44 98.05 99.61 99.61 99.61 99.61 99.61 99.61 99.61 99.61
5500.00 96.48 93.36 96.48 90.63 97.27 94.14 98.05 98.05 98.44 99.61 99.61 99.61 99.61 99.61 99.61 99.61 99.61
5000.00 92.97 96.09 92.58 96.48 94.92 98.83 96.09 96.09 96.88 98.83 98.83 99.61 99.61 99.61 99.61 99.61 99.61
4500.00 89.84 94.92 98.05 94.14 92.97 97.27 95.31 95.70 96.09 97.66 97.66 99.22 99.22 99.61 99.61 99.61 99.61
4000.00 87.89 92.97 95.31 92.97 91.80 95.70 93.75 95.70 95.31 96.88 96.88 97.66 99.61 99.61 99.61 99.61 99.61
3600.00 85.55 89.84 93.75 98.83 97.27 94.14 92.19 94.53 93.75 96.09 96.09 96.88 98.44 99.61 99.61 99.61 99.61
3200.00 83.59 88.28 90.63 96.48 96.09 92.97 91.02 92.58 92.58 94.53 94.92 95.70 97.27 98.83 99.61 99.61 99.61
2800.00 82.42 85.55 89.06 94.14 93.36 89.84 88.67 91.02 91.02 93.36 93.75 94.53 96.09 97.27 97.66 99.61 99.61
2400.00 78.13 82.03 83.98 89.06 89.45 86.33 85.55 87.89 89.84 92.19 92.97 94.14 94.92 96.09 96.48 99.22 99.61
2200.00 67.58 70.70 72.66 77.73 80.08 80.86 81.64 85.94 89.06 91.41 91.80 92.97 94.14 95.31 95.70 96.88 98.05
2000.00 64.06 65.63 67.97 71.48 75.78 80.08 82.03 84.77 87.11 89.06 89.84 90.23 90.23 91.41 92.97 94.92 95.70
TABLE: TPS Threshold Vs. RPM For Power Enrich. Mode
RPM % TPS
7500 19.92
7000 19.92
6500 19.92
6000 19.92
5500 19.92
5000 19.92
4500 19.92
4000 19.92
3600 30.08
3200 30.08
2800 39.84
2400 39.84
2000 39.84
1600 39.84
1200 39.84
800 39.84
400 39.84
TABLE: TPS Threshold for PE Vs RPM, (High Cool.)
RPM % TPS
6400 10.16
6000 10.16
5600 10.16
5200 10.16
4800 10.16
4400 10.16
4000 10.16
3600 10.16
3200 10.16
2800 10.16
2400 10.16
2000 10.16
1600 10.16
1200 10.16
800 19.92
400 39.84
0 39.84
TABLE: PE %Change to Fuel/Air Ratio Vs. Cool. Temp.
Deg C % Change
152 29.69
104 12.50
56 14.45
8 19.14
-40 35.55
TABLE: PE %Change to Fuel/Air Ratio Vs. RPM
RPM % Change
0.00
7500.00 24.22
7000.00 24.22
6500.00 24.61
6000.00 23.44
5500.00 19.53
5000.00 15.63
4500.00 12.11
4000.00 10.16
3600.00 7.81
3200.00 5.86
2800.00 3.91
2400.00 1.95
2000.00 0.00
1600.00 0.00
1200.00 0.00
800.00 0.00
400.00 0.00
TABLE: Target Idle RPM Vs. Coolant Temp. (In Drive)
Deg C Target Idle RPM
116 800.00
104 800.00
92 800.00
80 800.00
68 800.00
56 800.00
44 800.00
32 900.00
20 900.00
8 900.00
-4 1000.00
-16 1050.00
-28 1050.00
-40 1050.00
TABLE: Target Idle RPM Vs. Coolant Temp. (In P/N)
Deg C Target Idle RPM
116 0.00
104 0.00
92 0.00
80 0.00
68 0.00
56 0.00
44 0.00
32 0.00
20 0.00
8 0.00
-4 0.00
-16 0.00
-28 0.00
-40 0.00
TABLE: IAC Warm Park Position Vs Coolant Temp.
Deg. C IAC Steps
116 35.00
104 35.00
92 35.00
80 45.00
68 52.00
56 62.00
44 70.00
32 82.00
20 88.00
8 95.00
-4 102.00
-16 114.00
-28 134.00
-40 143.00
TABLE: Open Loop %Change to Fuel/Air Ratio Vs. Cool. Temp.
Deg C % Change
116 13.67
104 13.67
92 13.67
80 13.67
68 13.67
56 13.67
44 13.67
32 15.63
20 20.70
8 28.13
-4 39.06
-16 56.25
-28 73.44
-40 94.53
TABLE: Open Loop %Change to Fuel/Air Ratio Vs. MAP
Kpa % Change
100 14.06
95 14.06
90 14.06
85 14.06
80 14.06
75 12.89
70 12.11
65 10.16
60 7.81
55 7.03
50 5.86
45 5.08
40 3.91
35 3.13
30 3.13
25 2.34
20 0.00
TABLE: TCC Lock/Unlock %TPS Vs. Speed (Low Gears)
MPH % TPS
LOCK UNLOCK
100 0.00 0.00
92 0.00 0.00
84 0.00 0.00
76 0.00 0.00
68 0.00 0.00
60 0.00 0.00
52 0.00 0.00
44 0.00 0.00
36 0.00 0.00
28 0.00 0.00
20 0.00 0.00
12 0.00 0.00
TABLE: Coolant Temp. Compensation Spark Vs. Load
Deg C MAP (kpa)
20 30 40 50 60 70 80 90 100
116 0.00 0.00 0.00 0.00 -3.00 -3.00 -6.00 -6.00 -6.00
104 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 -3.00
92 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
80 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
68 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
56 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
44 1.00 1.00 1.00 1.00 1.00 1.00 1.00 1.00 2.00
32 2.00 2.00 2.00 2.00 2.00 1.00 1.00 1.00 2.00
20 3.00 3.00 3.00 2.00 2.00 2.00 2.00 2.00 3.00
8 4.00 4.00 5.00 5.00 5.00 5.00 5.00 5.00 5.00
-4 5.00 5.00 5.00 6.00 8.00 8.00 8.00 8.00 8.00
-16 5.00 5.00 5.00 6.00 8.00 8.00 8.00 8.00 8.00
TABLE: TCC Lock/Unlock %TPS Vs. Speed (High Gears)
MPH % TPS
LOCK UNLOCK
100 0.00 0.00
92 0.00 0.00
84 0.00 0.00
76 0.00 0.00
68 0.00 0.00
60 0.00 0.00
52 0.00 0.00
44 0.00 0.00
36 0.00 0.00
28 0.00 0.00
20 0.00 0.00
12 0.00 0.00
TABLE: Knock Retard Gain Factor Vs. RPM
RPM Gain
6400 18.00
6000 18.00
5600 18.00
5200 18.00
4800 18.00
4400 18.00
4000 18.00
3600 18.00
3200 18.00
2800 18.00
2400 18.00
2000 18.00
1600 18.00
1200 18.00
800 18.00
400 13.00
0 13.00
TABLE: Knock Retard Recovery Factor Vs. RPM
RPM
6400 0.12
6000 0.12
5600 0.12
5200 0.12
4800 0.12
4400 0.12
4000 0.12
3600 0.12
3200 0.12
2800 0.09
2400 0.06
2000 0.06
1600 0.05
1200 0.04
800 0.04
400 0.04
0 0.04
TABLE: BLM Cell RPM Boundaries
Boundary RPM
High 2600.00
Mid 2000.00
Low 1400.00
TABLE: BLM Cell MAP Boundaries
Boundary MAP (Kpa)
High 50.00
Mid 40.00
Low 35.00
TABLE: StartUp Enrichment Vs. Coolant Temp.
Deg. C % Change to AFR
116 5.08
104 5.08
92 5.08
80 14.84
68 14.84
56 19.14
44 28.13
32 31.25
20 39.84
8 62.50
-4 75.00
-16 85.94
-28 92.19
-40 99.61
TABLE: Accel. Enrich. Vs. Differential TPS (Mult)
%TPS Multiplier
50.0 0.25
46.9 0.25
43.8 0.25
40.6 0.25
37.5 0.25
34.4 0.50
31.3 0.63
28.1 0.63
25.0 0.63
21.9 0.75
18.8 1.03
15.6 1.09
12.5 1.16
9.4 1.25
6.3 1.31
3.1 1.50
0.0 1.50
TABLE: Accel. Enrich. Vs. Coolant Temp. (Mult.)
Deg. C Multiplier
128 0.08
116 0.14
104 0.20
92 0.23
80 0.30
68 0.36
56 0.41
44 0.52
32 0.66
20 0.75
8 0.94
-4 1.09
-16 1.25
-28 1.38
-40 1.50
TABLE: DFCO Enable TPS Threshold Vs. RPM
RPM %TPS
3600 1.56
3200 1.56
2800 1.17
2400 1.17
2000 0.78
1600 0.78
1200 0.39
800 0.39
400 0.39
0 0.39
TABLE: Accel Enrich Delta TPS PW Factor Vs Async Pulse
Pulse Mult.
8 0.00
7 0.00
6 0.00
5 0.00
4 0.00
3 0.00
2 2.00
1 3.98
TABLE: Accel Enrich Delta MAP PW Multiplier Vs. Delta MAP
Kpa Mult.
50 0.27
40 0.22
30 0.18
20 0.15
10 0.13
0 0.12
TABLE: Accel Enrich Delta MAP PW Multiplier Vs. Coolant Temp.
Deg. C Mult.
152 0.00
128 0.03
104 0.06
80 0.09
56 0.14
32 0.25
8 0.28
-16 0.41
-40 0.56
TABLE: Accel Enrich Delta MAP PW Decay Factor Vs. Coolant Temp.
Deg. C % Decay
152 50.00
128 50.00
104 46.09
80 46.09
56 39.84
32 39.84
8 39.84
-16 39.84
-40 39.84
TABLE: Accel Enrich Delta MAP Enable Threshold Vs TPS
%TPS Kpa
50.0 2.50
37.5 2.50
25.0 2.50
12.5 2.81
0.0 3.13
TABLE: IAC Manual Throttle Follower Offset Vs. MPH
MPH Steps
64 10.00
60 10.00
56 10.00
52 10.00
48 10.00
44 10.00
40 10.00
36 10.00
32 10.00
28 10.00
24 10.00
20 10.00
16 10.00
12 10.00
8 6.00
4 4.00
0 2.00
TABLE: Crank Fuel Pulse Width Vs. Coolant Temp.
Deg. C msec
116 3.20
104 3.20
92 3.20
80 3.20
68 3.60
56 4.00
44 4.00
32 8.80
20 12.00
8 24.00
-4 35.60
-16 53.20
-28 78.40
-40 88.40
TABLE: Crank Fuel PW Multiplier Vs. Ref. Pulses (1-16)
Ref. Pulse Multiplier
16 0.00
15 0.00
14 0.00
13 0.00
12 0.00
11 0.00
10 1.00
9 1.00
8 0.00
7 0.00
6 0.00
5 0.00
4 0.00
3 0.50
2 1.00
1 1.00
TABLE: Crank Fuel PW Multiplier Vs. Ref. Pulses (>17)
Ref. Pulse Multiplier
8 0.00
7 0.00
6 0.00
5 0.80
4 0.00
3 0.00
2 0.00
1 0.80
TABLE: Crank Fuel Delivery Delay Vs. MAT
Deg. C Ref. Pulses
152 1.00
140 1.00
128 1.00
116 1.00
104 1.00
92 1.00
80 1.00
68 1.00
56 1.00
44 0.00
32 0.00
20 0.00
8 0.00
-4 0.00
-16 0.00
-28 0.00
-40 0.00
TABLE: Left Fast O2 Rich/Lean Threshold Vs. Air Flow
gm/sec mV
128 566.37
96 530.98
64 513.28
32 477.88
0 424.78
TABLE: Right Fast O2 Rich/Lean Threshold Vs. Air Flow
gm/sec mV
128 566.37
96 530.98
64 513.28
32 477.88
0 424.78
TABLE: Left Slow O2 Rich/Lean Thresholds Vs. Air Flow
gm/sec Limit (mV)
Lower Upper
128 566.37 566.37
96 530.98 530.98
64 513.28 513.28
32 477.88 477.88
0 424.78 424.78
TABLE: Right Slow O2 Rich/Lean Thresholds Vs. Air Flow
gm/sec Limit (mV)
Lower Upper
128 566.37 566.37
96 530.98 530.98
64 513.28 513.28
32 477.88 477.88
0 424.78 424.78
TABLE: Idle Speed Timeout IAC Steps Vs. Coolant Temp.
Deg. C Steps
152 10.00
140 10.00
128 38.00
116 38.00
104 34.00
92 26.00
80 23.00
68 20.00
56 20.00
44 20.00
32 20.00
20 20.00
8 20.00
-4 20.00
-16 20.00
-28 20.00
-40 20.00
TABLE: Low Octane ESC Base Retard Vs. RPM
RPM Deg.
3200 0.00
2800 0.00
2400 0.00
2000 0.00
1600 0.00
1200 0.00
800 0.00
400 0.00
0 0.00
TABLE: Low Octane ESC Retard Multipier Vs. RPM
RPM Mult.
6400 0.56
5600 0.56
4800 0.56
4000 0.56
3200 0.75
2400 1.00
1600 1.00
800 1.00
0 1.00
TABLE: Low Octane ESC Retard Multipier Vs. MAP
kPa Mult.
100 1.00
95 1.00
90 1.00
85 1.00
80 1.00
75 1.00
70 1.00
65 0.69
60 0.50
55 0.37
50 0.25
45 0.12
40 0.00
35 0.00
30 0.00
25 0.00
20 0.00
TABLE: Injector PW Correction Vs. Battery Voltage
VDC (Vbatt) usec Added
25.6 1281.76
24.0 1373.31
22.4 1525.90
20.8 1709.01
19.2 1953.15
17.6 2288.85
16.0 2777.14
14.4 3295.94
12.8 4516.66
11.2 7782.09
9.6 7782.09
8.0 7782.09
6.4 7782.09
4.8 7782.09
3.2 549.32
1.6 549.32
0.0 976.58
TABLE: Inverse MAT Term Lookup Delta Multiplier Vs Airflow
gm/sec Multiplier
256 0.10
240 0.10
224 0.10
208 0.11
192 0.13
176 0.13
160 0.15
144 0.16
128 0.18
112 0.19
96 0.20
80 0.22
64 0.27
48 0.28
32 0.32
16 0.45
0 0.47
TABLE: MAT Compensation Counts Vs. MAT
MAT (Deg C) Counts
152 150.00
140 150.00
128 150.00
116 150.00
104 150.00
92 150.00
80 150.00
68 137.00
56 124.00
44 116.00
32 108.00
20 95.00
8 77.00
-4 59.00
-16 46.00
-28 33.00
-40 20.00
TABLE: Traction Control Spark Retard Vs. RPM
RPM Deg Retard
6400 0.00
6000 0.00
5600 0.00
5200 0.00
4800 0.00
4400 0.00
4000 0.00
3600 0.00
3200 0.00
2800 0.00
2400 0.00
2000 0.00
1600 0.00
1200 0.00
800 0.00
400 0.00
0 0.00
FLAG: Data Stream Fuel Enable (X = Enabled) Not Set
SCALAR: Min. Async Pulse Width 2.00
SCALAR: Max. Async Pulse Width 11.11
SCALAR: Throttle Follower Slope Gain-Stps/%TPS 1.13
SCALAR: Throttle Follower Max. Steps 50.00Last edited by jaysz2893; 05-21-2015 at 05:14 PM.
-
The Following User Says Thank You to jaysz2893 For This Post:
-
05-21-2015, 08:15 PM #24LTX Master
- Status
- Offline
- Join Date
- Feb 2014
- Name
- 95albinobird
- Vehicle
- 95 firehawk tribute
- Location
- mooresville nc
- Posts
- 772
i you may be overthinking it.....i often go with the K.I.S.S method (Keep It Simple Stupid). i'm NOT saying you are stupid in anyway.
i would not do anything to alter my emissions controls and i am emissions exempt in my state.i still got emission legal headers in a way i think gm knows better than most of us to a point when it comes to programing their cars emission system
here is something to read
http://www.smogtips.com/failed-high-hydrocarbons-HC.cfm
you say you did a egr delete
http://www.smogtips.com/failed-high-...rous-oxide.cfm
i answered your post saying could be a bad cat then i found this is in the links.
3. Defective Catalytic Converter (CAT) Some vehicle manufactures have designed their cars to operate without EGR valves. Non-EGR equipped vehicles rely heavily on the Catalytic Converter to assist in the reduction of NO. These vehicles have tendencies to develop CAT problems sooner then those which are equipped. If you own a non-EGR equipped vehicle, and have failed the emissions test for high NOx, pay close attention to the Catalytic Converter.
i have had bad o2 sensors that never set a code but were bad.we looked at the readings from the o2 sensor and it was out of spec.could be that could be a injector leaking/hanging up from the fuel sitting.
sorry fuc it i'm no help
wait a minute yes i am get away from the communist in NJ and NY with their CRAZY gun control laws
move to north carolina and you will never have a problem again with emissions on that car LOL.Last edited by 95albinobird; 05-21-2015 at 08:57 PM.
-
The Following User Says Thank You to 95albinobird For This Post:
-
05-22-2015, 02:57 AM #25Lurker
- Status
- Offline
- Join Date
- Feb 2015
- Name
- Sean Cross
- Vehicle
- 1995 Camaro Z28
- Location
- Lake County, IL (Chicagoland)
- Posts
- 143
If anyone mentioned it I missed it but have you checked your O2 sensors to make sure they are capable of ~.9v when you stab the throttle.
If either/both are weak you will run richer than previously.
-
05-22-2015, 05:02 AM #26Founding Member
- Status
- Offline
- Join Date
- Sep 2008
- Name
- Jay
- Vehicle
- 93 Ultra Z
- Location
- Delaware
- Posts
- 3,144
I am going to scan the car this weekend and look heavy at the injectors duty cycle and the o2 sensors. I have a spare set of new o2 sensors and may just swap them out. The cats are probably ok as the NOX numbers are good. I have a spare set of them too... lol... but swapping them is not as easy. I have passed many times with the egr deleted before. I appreciate all the feedback. This is why I love this community!
-
The Following User Says Thank You to jaysz2893 For This Post:
-
05-23-2015, 06:41 AM #27Founding Member
- Status
- Offline
- Join Date
- Sep 2008
- Name
- Jay
- Vehicle
- 93 Ultra Z
- Location
- Delaware
- Posts
- 3,144
Getting ready to go to a local show. Gonna scan on the way. I parked the car in the house garage last night and I notice a pretty good smell of gas. I looked under the hood and it does not appear to be an external leak. I have noticed that the pump needs to prime every time I start the car, regardless of how long it was off. I wonder if I have some leaking injectors from the ethanol due to the time in storage?
-
The Following User Says Thank You to jaysz2893 For This Post:
-
05-23-2015, 08:06 AM #28Xtreme Member
- Status
- Offline
- Join Date
- Nov 2012
- Name
- Shaun
- Vehicle
- 1994 Formula
- Location
- Phillipsburg NJ
- Posts
- 7,266
Supporting Member2021 Charger Scat 392
1994 Firebird Formula 381 stroker - Carrying the torch! - 9.90 @ 134.3mph on a 200 shot
The wrench/driver for LTConvert's 94 Z28- Ellwein 383/LE Trickflows/ D1SC / CPT Ultra Pro Race 4L60E
10.78 @ 125mph. Shooting for 9.99 for Frank Cahall!
-
The Following User Says Thank You to SSlowBoat For This Post:
-
05-23-2015, 10:32 AM #29"The Rock"
- Status
- Offline
- Join Date
- Jul 2009
- Name
- Popo
- Vehicle
- 1996 Impala with the heart of the old camaro. 1993 Corvette..
- Location
- Shillington, Pennsylvania, United States
- Posts
- 61,345
Our BIG MOMENT @ the 2012 LTXshootout
http://www.facebook.com/photo.php?v=521756391174175
1996 Camaro Z28: RIP 09/25/2016
1994 Trans Am GT: SOLD 05/2017
1985/1996GS clone: SOLD
1996 Impala SS H/C, LT, with true dual exhaust, 4.10s, lowered, with CPT trans, many cosmetic mods, and a whole lot more to come...
2002 Caddilac EscaladeL CAI, lowered, 6.0 , AWD..
-
05-23-2015, 02:34 PM #30Founding Member
- Status
- Offline
- Join Date
- Sep 2008
- Name
- Jay
- Vehicle
- 93 Ultra Z
- Location
- Delaware
- Posts
- 3,144
Bookmarks